Heated Steering Wheel Retrofit - updated with information

[dolsen]

Sounds great, but my above post still applies where you need to see what your current asbuilt values are so you can determine what you need to input. How familiar are you with Forscan?

@Buddy726 b-real has nailed it. You have to have a passing knowledge of what FORScan is and how it works to be able to do the changes needed. Someone else COULD do it all for you, but I doubt it would be free. You have to be willing to read and research a little bit as the changes required are different from truck to truck. Start with Livnitups forscan sheet and use the motor craft as builts page to figure out what your own values are and what they should changed to

Sponsored

 

[Buddy726]

Iv used forscan before. Other on here told me on this project that just save the value from the HVAC that came with the truck and change it out with the new one and program the new one with the values from the original one.

 

[dolsen]

Iv used forscan before. Other on here told me on this project that just save the value from the HVAC that came with the truck and change it out with the new one and program the new one with the values from the original one.

That’s for the HVAC module swap if you’re going from a unit without temp readouts on the dials to a unit with temp readouts on the dials. But if you’re retrofitting a heated steering wheel, there are more changes required.

 

[Buddy726]

Well Iam not. My heated steering wheel is there

 

[B-real]

Without going back through all 55 pages of this thread to determine how to physically do the hardware swaps as well as what Forscan changes need to be made (as I assume this info is here somewhere already), here is what you need to look at for Forscan (all straight from the Forscan spreadsheet). Before you make these changes, load your original asbuilt files to the HVAC and SCCM, then go in and make the adjustments you determine need to be done.

HVAC Module

				Heated Steering Wheel (HSW) • Heated Windscreen (HW) • Battery Pack Cooler (BPC) • Front In-car temp sensor (FI)
733-01-02	xxx*	xxxx	xx--	0 =	HSW Vehicle does NOT contain a HSW (Heated steering wheel) • HW Vehicle does NOT contain a Heated Windscreen (HWS) • BPC Vehicle does NOT contain a battery pack cooler • FI Front In-car sensor NOT present in vehicle		8 =	HSW Vehicle contains a HSW (Heated steering wheel) • HW Vehicle does NOT contain a Heated Windscreen (HWS) • BPC Vehicle does NOT contain a battery pack cooler • FI Front In-car sensor NOT present in vehicle
				1 =	HSW Vehicle does NOT contain a HSW (Heated steering wheel) • HW Vehicle does NOT contain a Heated Windscreen (HWS) • BPC Vehicle does NOT contain a battery pack cooler • FI Front In-car sensor present in vehicle		9 =	HSW Vehicle contains a HSW (Heated steering wheel) • HW Vehicle does NOT contain a Heated Windscreen (HWS) • BPC Vehicle does NOT contain a battery pack cooler • FI Front In-car sensor present in vehicle
2 =	HSW Vehicle does NOT contain a HSW (Heated steering wheel) • HW Vehicle does NOT contain a Heated Windscreen (HWS) • BPC Vehicle contains a battery pack cooler • FI Front In-car sensor NOT present in vehicle		A =	HSW Vehicle contains a HSW (Heated steering wheel) • HW Vehicle does NOT contain a Heated Windscreen (HWS) • BPC Vehicle contains a battery pack cooler • FI Front In-car sensor NOT present in vehicle
3 =	HSW Vehicle does NOT contain a HSW (Heated steering wheel) • HW Vehicle does NOT contain a Heated Windscreen (HWS) • BPC Vehicle contains a battery pack cooler • FI Front In-car sensor present in vehicle		B =	HSW Vehicle contains a HSW (Heated steering wheel) • HW Vehicle does NOT contain a Heated Windscreen (HWS) • BPC Vehicle contains a battery pack cooler • FI Front In-car sensor present in vehicle
4 =	HSW Vehicle does NOT contain a HSW (Heated steering wheel) • HW Vehicle contains a Heated Windscreen (HWS) • BPC Vehicle does NOT contain a battery pack cooler • FI Front In-car sensor NOT present in vehicle		C =	HSW Vehicle contains a HSW (Heated steering wheel) • HW Vehicle contains a Heated Windscreen (HWS) • BPC Vehicle does NOT contain a battery pack cooler • FI Front In-car sensor NOT present in vehicle
5 =	HSW Vehicle does NOT contain a HSW (Heated steering wheel) • HW Vehicle contains a Heated Windscreen (HWS) • BPC Vehicle does NOT contain a battery pack cooler • FI Front In-car sensor present in vehicle		D =	HSW Vehicle contains a HSW (Heated steering wheel) • HW Vehicle contains a Heated Windscreen (HWS) • BPC Vehicle does NOT contain a battery pack cooler • FI Front In-car sensor present in vehicle
6 =	HSW Vehicle does NOT contain a HSW (Heated steering wheel) • HW Vehicle contains a Heated Windscreen (HWS) • BPC Vehicle contains a battery pack cooler • FI Front In-car sensor NOT present in vehicle		E =	HSW Vehicle contains a HSW (Heated steering wheel) • HW Vehicle contains a Heated Windscreen (HWS) • BPC Vehicle contains a battery pack cooler • FI Front In-car sensor NOT present in vehicle
7 =	HSW Vehicle does NOT contain a HSW (Heated steering wheel) • HW Vehicle contains a Heated Windscreen (HWS) • BPC Vehicle contains a battery pack cooler • FI Front In-car sensor present in vehicle		F =	HSW Vehicle contains a HSW (Heated steering wheel) • HW Vehicle contains a Heated Windscreen (HWS) • BPC Vehicle contains a battery pack cooler • FI Front In-car sensor present in vehicle

SCCM

724-01-01

xxxx

*xxx

--

HSW_Present_Cfg: 0=Disable 8=Enable

HSW=Heated Steering Wheel

				HSW_Level_3_TempSetPt (HSWLTSP)
724-06-01	*xxx	xxxx	--	0 =	HSWLTSP 24°C		8 =	HSWLTSP 32°C
				1 =	HSWLTSP 25°C		9 =	HSWLTSP 33°C
2 =	HSWLTSP 26°C		A =	HSWLTSP 34°C
3 =	HSWLTSP 27°C		B =	HSWLTSP 35°C
4 =	HSWLTSP 28°C		C =	HSWLTSP 36°C
5 =	HSWLTSP 29°C		D =	HSWLTSP 37°C
6 =	HSWLTSP 30°C		E =	HSWLTSP 38°C
7 =	HSWLTSP 31°C		F =	HSWLTSP 39°C
				HSW_AutoShutOffTime (HSWASOT)
724-06-01	x*xx	xxxx	--	0 =	HSWASOT Off (No AutoShutOff)		4 =	HSWASOT 30 min
				1 =	HSWASOT 10 min		5 =	HSWASOT 40 min
2 =	HSWASOT 15 min		6 =	HSWASOT 50 min
3 =	HSWASOT 20 min		7 =	HSWASOT 60 min

APIM - 7D0

				Climate Front Zones (CFZ) • Smart Auto (SA) • Rear Climate (RC) • Heated Steering Wheel (HSW)
7D0-02-01	xxxx	*xxx	xx--	0 =	CFZ Dual Zone • SA Disabled • RC Not Available • HSW Not Available (or Hard Button Control)		8 =	CFZ Single Zone • SA Disabled • RC Not Available • HSW Not Available (or Hard Button Control)
				1 =	CFZ Dual Zone • SA Disabled • RC Not Available • HSW Available		9 =	CFZ Single Zone • SA Disabled • RC Not Available • HSW Available
2 =	CFZ Dual Zone • SA Disabled • RC Available • HSW Not Available (or Hard Button Control)		A =	CFZ Single Zone • SA Disabled • RC Available • HSW Not Available (or Hard Button Control)
3 =	CFZ Dual Zone • SA Disabled • RC Available • HSW Available		B =	CFZ Single Zone • SA Disabled • RC Available • HSW Available
4 =	CFZ Dual Zone • SA Enabled • RC Not Available • HSW Not Available (or Hard Button Control)		C =	CFZ Single Zone • SA Enabled • RC Not Available • HSW Not Available (or Hard Button Control)
5 =	CFZ Dual Zone • SA Enabled • RC Not Available • HSW Available		D =	CFZ Single Zone • SA Enabled • RC Not Available • HSW Available
6 =	CFZ Dual Zone • SA Enabled • RC Available • HSW Not Available (or Hard Button Control)		E =	CFZ Single Zone • SA Enabled • RC Available • HSW Not Available (or Hard Button Control)
7 =	CFZ Dual Zone • SA Enabled • RC Available • HSW Available		F =	CFZ Single Zone • SA Enabled • RC Available • HSW Available

				Climate Auto Heated Steering Wheel (CAHSW) • Mirror Defrost (MD) • Front Dual Zone Dual / Link Button (FDZDLB)
7D0-02-02	x*xx	xxxx	xx--	0 =	CAHSW Disabled • MD Off • FDZDLB Dual Button		4 =	CAHSW Enabled • MD Off • FDZDLB Dual Button
				1 =	CAHSW Disabled • MD Off • FDZDLB Link Button		5 =	CAHSW Enabled • MD Off • FDZDLB Link Button
2 =	CAHSW Disabled • MD On • FDZDLB Dual Button		6 =	CAHSW Enabled • MD On • FDZDLB Dual Button
3 =	CAHSW Disabled • MD On • FDZDLB Link Button		7 =	CAHSW Enabled • MD On • FDZDLB Link Button

 

[JScaro]

@Buddy726
Best to get a VIN on a truck comparable to yours and compare the AS-Built values. Here's a PDF of mine for a 502 Lariat.

 

[tilefordude]

Does anyone know the part number for pin 15? I want to add the pin to make it official. Where do I purchase the pins ?

 

[Buddy726]

i just did the hvac and the heated steering wheel on my 23 platinum. hvac i believe is all done. put the new clock spring in i got from boosted grey goose, but he made a mistake. he told me all i need was the clock spring. he was wrong. i need the part that the clock spring clips into and the directional switch clips into . the problem is the two pins on the back of the clock spring dont go all the way threw to the wire harness connector. and body know the part number that part i need?

 

[Buddy726]

Ok guys, just a quick update.
I ordered the ML3Z-3F791-HB (SCCM) (see pictures for reference) for my 23 Raptor and was able to finish the heated steering wheel retrofit. It seems like the ML3Z-3F791-BB is only suitable for all other trims besides the Raptor as it doesn't recognize the Raptor specific left and right steering wheel buttons.

I now have a brand new ML3Z-3F791-BB unit at home that I will sell.

is this the one for a 23 platinum? i have the clock spring.

 

[superfordman]

is this the one for a 23 platinum? i have the clock spring.

Yes, you need a ML3Z-3F791-BB

 

[Buddy726]

Thanks that guy boosted grey goose only sold me half of the clock spring and now denies that he did and I have a receipt that shows that he did so I don’t know what his problem is. I’m sure other people have problems with his company.

 

[xlover]

Thanks that guy boosted grey goose only sold me half of the clock spring and now denies that he did and I have a receipt that shows that he did so I don’t know what his problem is. I’m sure other people have problems with his company.

Did you order the online kit? The pics are right on the site so I think it would be hard for him to shortchange you. FYI I ordered the online kit and it came exactly as pictured with the clockspring + SCCM combo (with wiper stalk), hvac module, and wiring harness in the box so something is definitely not right

Edit added link for context
https://www.boostedgreygoosedesigns...-2022-ford-f150-heated-steering-wheel-harness

 

[Buddy726]

That great, I talked to him before he sold kits.

 

["Steve"]

came across this one another forum. anyone seen before and know part number?

 

[B-real]

came across this one another forum. anyone seen before and know part number?

Dont know the PN, but looks like it would be out of a XLT 302a w/heated seats and steering wheel, or maybe a 500a or 501a Lariat w/out cooled seats

Sponsored